Often asked: How To Change Clutch Cable On Motorcycle?

How much does it cost to replace a clutch cable on a motorcycle?

How much does it cost to replace a clutch cable on a motorcycle? The average cost for clutch cable replacement is between $146 and $176. Labor costs are estimated between $68 and $86 while parts are priced between $78 and $90.

When should I replace motorcycle clutch cable?

Not Getting Into Gear If it becomes impossible to get a motorcycle to shift into certain gears, it is time to replace the clutch. If the gear shift lever goes up and down freely, the motorcycle owner should plan for a clutch replacement.

How do I know if my clutch cable is bad on my motorcycle?

To tell if your motorcycle clutch is bad, you ‘ll need to look for signs such as unexplained high revs and lowered gas mileage. Other signs of a bad clutch may also include a stuck clutch lever, hard shifts accompanied by a clunking sound or jerk, and difficulty getting the motorcycle to shift gears.

How long does it take to replace a clutch cable?

About an hour. Fred/edde and the like could probably pull it through in 30 minutes.

How do I know if I need a new clutch cable?

Symptoms of a Bad or Failing Clutch Cable

• Transmission slips out of gear. A bad clutch cable can sometimes cause a transmission to slip and pop out of gear.
• Hard clutch pedal. Another symptom of a problem with the clutch cable is a hard clutch pedal.
• Clutch pedal sinks to the floor.

Can you drive with broken clutch?

Driving On A Damaged Clutch You should never drive on a damaged clutch, not only is it very dangerous, but it can also cause further, more serious damage to your clutch and gearbox which will be expensive to repair.

How much does it cost to replace a clutch cable?

The average cost for clutch cable replacement is between $146 and $176. Labor costs are estimated between $68 and $86 while parts are priced between $78 and $90.

How long should a motorcycle clutch cable last?

The lucky thing is, breaking a clutch cable is a rare occurrence. Grease yours once a year or so and replace it every 30 or 40,000 miles (consult your owners manual for service schedule) and you’ll likely never break one. Clutch cables break by fraying, popping one strand after another over time.

Is it bad to hold in the clutch on a motorcycle?

No, this won’t hurt your motorcycle in any way, and you will save fuel, because your engine at idling speed will obviously use up much less fuel than having it at higher revolutions, but disengaging your clutch will also disengage your engine braking, and add to the stress on the brakes if you need to slow down.

How long should a motorcycle clutch last?

Typically you can expect your a motorcycle clutch to last between 20 000 and 60 000 miles. A clutch that is often slipped in the friction zone and that is not properly maintained may need replacement after as little as 5 000 miles, while many riders do well over 100 000 miles on the original clutch.

What causes clutch cable to snap?

What can cause a snapped clutch cable? Bad clutch pressure plate – The clutch pressure plate applies pressure to the clutch, holding it against the flywheel. Sometimes, a bad or damaged pressure plate can put high levels of stress onto the clutch cable, leading to it snapping and breaking.